聯系方式

公司名稱：承德萬洋活性炭廠

公司地址：承德縣下板城工業區

陳經理

固定

椰殼活性炭簡介

椰殼活性炭采用菲律賓、印尼等國家進口優質椰殼為原料，采用世界先進技術的回轉式高溫活化爐，經科學配方，精制而成。外觀呈黑色顆粒狀。優點是孔隙結構發達，比表面積大，吸附性能強，化學性能穩定，易再生。該產品脫色、除臭快，產品強度高，使用壽命長。

產品主要用于飲用水、純凈水、制酒、飲料、工業污水的凈化、脫色、脫氯、除臭；也可用于煉油行業的脫硫醇等。

椰殼活性炭特性

1、椰殼活性炭屬于果殼活性炭類別，其主要特點是密度小、手感輕，拿在手里的重量 明顯比煤質活性炭輕。相同重量的活性炭，椰殼活性炭體積一般大于煤質活性炭。

2、椰殼活性炭形狀一般為破碎顆粒狀、片狀，而成型活性炭，如柱狀、球狀活性炭，多為煤質炭。

3、因椰殼活性炭密度小，手感輕，因此可以將活性炭放到水里，煤質炭一般沉底較快，而椰殼活性炭浮在水中的時間更長，隨著活性炭吸附水分子 達到飽和，加重自身重量才會逐步全部沉入水底，當活性炭全部沉底后，會看見每顆活性炭外面都包裹著一個小氣泡，晶瑩剔透，非常有趣。

4、椰殼活性炭為小分子孔隙結構，將活性炭放到水里，其吸附水分子時所排空氣會產生許多非常細小的水泡（肉眼剛好 能看見），密密麻麻的不停浮向水面。而煤質活性炭一般為大分子孔隙結構，所產生的氣泡也相對較大。

椰殼活性炭理化指標

椰殼活性炭用途
1、空氣凈化；
2、污水處理場排氣吸附；
3、飲料水處理；
4、電廠水預處理；
5、廢水回收前處理；
6、生物法污水處理；
7、有毒廢水處理；
8、石化無堿脫硫醇；
9、溶劑回收（因?yàn)榛钚蕴靠晌接袡C(jī)溶劑）；
10、化工催化劑載體；
11、濾毒罐；
12、黃金提取；
13、化工品儲存排氣凈化；
14、制糖、酒類、味精醫藥、食品精制、脫色；
15、乙烯脫鹽水填料；
16、汽車尾氣凈化；
17、PTA氧化裝置凈化氣體；
18、印刷油墨的除雜；

椰殼活性炭的的使用方法
1、即使有再好的空氣凈化活性炭產品，人在封閉的室內時間過長，也易導致一些病癥。對于用戶來說，要時常注意開窗通風，平時多注意鍛煉身體。
2、活性炭用量，原理上是越多越好，使用量越大吸附的有害氣體就越多,特別是家里有老人或孕婦兒童更要多用！但應該從經濟方面考慮較適合的空氣凈化炭用量。
3、甲醛的排放隨溫度和濕度的上升而增加。遇到潮濕悶熱天氣，即使用了活性炭，室內的甲醛濃度此時也會出現反彈，但不必?fù)?dān)心，空氣凈化活性炭會在幾天內將其吸附恢復正常。
4、椰殼活性炭在運輸過程中，防止與堅硬物質混狀，不可踩、踏，以防炭粒破碎，影響質量。
5、儲存應儲存于多孔型吸附劑，所以在運輸儲存和使用過程中，都要 防止水浸，因水浸后，大量水充滿活性空隙，使其失去作用。
6、防止焦油類物質在使用過程中，應禁止焦油類物質帶入活性炭床，以免堵塞活性炭空隙，使其失去吸附作用。較好有除焦設備凈化氣體。
7、防火活性炭在儲存或運輸時，防止與火源直接接觸，以防著火、活性炭再生時避免進氧并再生徹底，再生后必須用蒸汽冷卻降至80以下，否則溫度高，遇氧，活性炭自燃。

活性炭注意事項

1、活性炭在運輸過程中，防止與堅硬物質混狀，不可踩、踏，以防炭粒破碎，影響質量。

2、儲存應儲存于多孔型吸附劑，所以在運輸儲存和使用過程中，都要 防止水浸，因水浸后，大量水充滿活性空隙，使其失去作用。

3、活性炭防止焦油類物質在使用過程中，應禁止焦油類物質帶入活性炭床，以免堵塞活性炭空隙，使其失去吸附作用。較好有除焦設備凈化氣體。

4、防火活性炭在儲存或運輸時，防止與火源直接接觸，以防著火、活性炭再生時避免進氧并再生徹底，再生后必須用蒸汽冷卻降至80以下，否則溫度高，遇氧，活性炭自燃。

活性炭吸附簡介

活性炭對水體中的揮發性有機物有比較好的吸附效果，可使水體中各種揮發性有機物去除率達到2565。比較各種不同分子量有機物的吸附規律可以看出，對于揮發性有機物，分子量越大，它們的去除率就越高。這與 與陽離子嫩黃的吸附規律類似，即對于水體中的小分子有機物而言，分子量越大，越容易被活性炭吸附。活性炭對分子量小于480以下的可提取有機物有著很好的去除效果，而對大分子有機物的去除效率很低。這主要是由于活性炭的微孔結構空問位阻效應，酞大的有機物分子不能進入到活性炭的孔隙內部，只能在活性炭的表面吸附，這樣它在活性炭上的有效吸附位下降，致使其吸附效率較小。

活性炭對揮發性有機物與可提取有機物吸附有著較大的差別。揮發性有機物隨分子量的增大，其吸附效果越好，而可提取有機物隨分子量的減小，其吸附效果越好。這主要是由于揮發性的有機物主要是一些極性比較小的有機物，而可提取的有機物是極性比較大的有機物，活性炭本身可以看作是一個非極性吸附劑，對水中非極性物質的吸附能力大于極性物質的吸附能力。而且，吸附質分子大小與活性炭呈一定比例時，較有利于吸附。對于極性較小的分子，分子量越大，越有利于吸附。

活性炭對水體中各種有機物的吸附有非常大的競爭性，其對各種有機物吸附量的大小不僅與有機物的分子結構有關，而且與水體中有機物種類的多寡有關。同時，對于揮發性有機物與可提取有機物，它們在活性炭上的吸附量與分子量的大小關系截然相反。可提取有機物隨分子量的增大，其吸附性能減弱;而揮發性有機物隨分子量增大起吸附性能亦增大。

英文翻譯

Contact information:

Company Name: Chengde Wanyang Activated Carbon Factory

Address: Chengde County xiabancheng Industrial Zone

Contact: Chen Manage

Phone:

Coconut shell activated carbon
Coconut shell activated carbon with the Philippines, Indonesia and other countries import high-quality coconut shell as raw material, adopts the world advanced technology of the rotary heat activation furnace, through scientific formula, refined but become.In black granular appearance.Advantage is developed pore structure, specific surface area, strong adsorption properties, stable chemical performance, easy to regeneration.This product is decolorizing, deodorant is fast, the product high strength, long service life.
Products are mainly used for drinking water, pure water, wine, beverage, industrial wastewater purification, decolorization, dechlorination, deodorant;Also can be used in oil refining industry to take off the mercaptan, etc.
Coconut shell activated carbon
1, coconut shell activated carbon belong to the type of nut shell activated carbon, its main characteristic is small density, light touch, in his hand the weight significantly lighter than coal activated carbon.The same weight of activated carbon, coconut shell activated carbon generally greater than the volume of coal activated carbon.
2, coconut shell activated carbon is commonly broken granule, flake, and forming activated carbon, such as column, globular activated carbon, coal char.
3, because of coconut shell activated carbon density is small, feel is light, so you can put the active carbon in the water, coal quality carbon sink generally faster, and coconut shell activated carbon floating in the water for longer periods of time, as the saturated activated carbon adsorption of water molecules, increase its weight will gradually sink entirely, when activated carbon sink after all, will see each activated carbon is wrapped in a small bubble outside, glittering and translucent get rid of, very interesting.
4, coconut shell activated carbon pore structure for small molecules, and put the active carbon in the water, the adsorption of water when the exhaust air will produce many very small blisters (just to the naked eye Can see), intensity of float to the surface.Macromolecular, pore structure and coal activated carbon is commonly produced by the bubble is also relatively large.

Coconut shell activated carbon use
1, air purification;
2, the sewage farm exhaust adsorption;
3, potable water treatment;
4, power plant water pretreatment;
5, waste water recycling before treatment;
6, biological wastewater treatment;
7, toxic wastewater treatment;
8, petrochemical non-alkali mercaptan;
9, solvent recovery (because of the activated carbon adsorption of organic solvent);
10, chemical catalyst carrier;
11, canister;
12, gold extraction;
13, chemical storage exhaust purification;
14, sugar, alcohol, monosodium glutamate, medicine, food, refining, decolorization;
15, ethylene desalted water packing;
16, automobile exhaust purification;
17, PTA oxidation device to purify the gas;
18, the printing ink removing impurity;
The use of coconut shell activated carbon
1, even if is again good to activate carbon products, air purification, the person in a closed indoor time is too long, also easy to cause some disorders.For users, to pay attention to open a window ventilated, often pay more attention to physical exercise at ordinary times.
2, the dosage of activated carbon, in principle is the more the better, the use of the more the greater the adsorption of harmful gas, especially families with elderly or pregnant women children more to use!But should consider the most suitable air purification from the aspects of economic coal consumption.
3, formaldehyde emission increases with the rise of temperature and humidity.In the humid weather, that is, using the activated carbon, the indoor formaldehyde concentration at this time will be a rebound, but don't worry, air purification activated carbon would be its adsorption in a few days back to normal.
4, coconut shell activated carbon in the process of transportation, prevent and hard material mix, do not step on, step, in case of charcoal grain crushing, affect the quality.
More than 5, storage should be stored in the groove adsorbent, so in the process of transportation storage and use, will absolutely prevent water immersion, due to flooding, after a lot of water is full of activity space, make them.
6, prevent tar material in use process, should be prohibited from tar class material to the activated carbon bed, lest jam activated carbon, lose its adsorption.It is better for decoking equipment to purify the gas.
7, fire activated carbon during storage or transportation, avoid direct contact with fire, in case of fire, into the oxygen and regeneration completely avoid when activated carbon regeneration, regeneration after have to use steam cooling down to under 80 , otherwise the temperature is high, meet oxygen, activated carbon combustion.
Activated carbon
1, the activated carbon in the process of transportation, prevent and hard material mix, do not step on, step, in case of carbon particle breakage, affect the quality.
2, storage should be stored in the groove adsorbent, more so in the process of transportation storage and use, will absolutely prevent water immersion, due to flooding, after a lot of water is full of activity space, lose its effect.
3, activated charcoal to prevent tar material in use process, should be prohibited from tar class material to the activated carbon bed, lest jam activated carbon, lose its adsorption.It is better for decoking equipment to purify the gas.
4, fire activated carbon during storage or transportation, avoid direct contact with fire, in case of fire, into the oxygen and regeneration completely avoid when activated carbon regeneration, regeneration after have to use steam cooling down to under 80 , otherwise the temperature is high, meet oxygen, activated carbon combustion.
Activated carbon adsorption
Activated carbon to volatile organic compounds in water body has better adsorption effect, can make all kinds of volatile organic compounds in water removal rate reached 25 65.Compare a variety of different molecular weight organic compound adsorption law can be seen that for volatile organic compounds, the larger the molecular weight, the higher the removal rate of them.This is similar to phenol adsorption law of cationic light yellow, namely for small molecule organic matter in water, the larger the molecular weight, the more easily by activated carbon adsorption.Activated carbon to extractable organic matter under molecular weight is less than 480 had a very good removal efficiency, and on the macromolecular organic matter removal efficiency is very low.This is mainly due to the microporous structure of the activated carbon empty asked steric effect, too large organic molecules to the interior of activated carbon pore, only on the surface of activated carbon adsorption, so that it effectively on activated carbon adsorption decline, leading to the adsorption efficiency is small.
Activated carbon can be extracted volatile organic compounds and organic adsorption has a larger difference.Volatile organic compounds with the molecular weight increased, and its adsorption effect, the better, and the decrease of the extractable organic compounds with molecular weight, the better its adsorption effect.This is mainly due to the volatile organic matter is mainly some smaller polarity organic matter, and the extractable organic matter is the polarity of organic material, activated carbon itself can be thought of as a non-polar adsorbent, the adsorption capacity of nonpolar substances in water is greater than the polar material adsorption ability.And the size of the adsorbate molecule and activated carbon show a certain proportion, the most conducive to the adsorption.For small polar molecules, molecular weight, the greater the more conducive to the adsorption.
Activated carbon for the adsorption of various organic compounds in water has great competitive, its size of various organic adsorption is not only related to the molecular structure of organic matter, but also related to the types of organic matter in water amount.At the same time, for can be extracted volatile organic compounds and organic compounds, they are on the activated carbon adsorption quantity and the size of the molecular weight of the opposite relationship.Extractable organic matter along with the increase of molecular weight and its adsorption performance;The volatile organic compounds with the increase of molecular weight adsorption performance has also increased.

產品圖片

聯系方式

公司名稱：承德萬洋活性炭廠

公司地址：承德縣下板城工業區

陳經理

固定

Contact information:

Company Name: Chengde Wanyang Activated Carbon Factory

Address: Chengde County xiabancheng Industrial Zone

Contact: Chen Manage

Phone: